At a weight of 5,6721b (2,572kg), the prototype demonstrated a speed of 315mph (506km/h) at the Merlin's rated altitude of 16,200ft (4, 937m)with 61b/sq in boost, After taking off into a 5mph (8km/h) wind with a run of 795ft (242m) to reach the 81mph (180km/h) lift-off speed, the Hurricane climbed to 15,000ft (4,570m) in 5.7 minutes and to 20,000ft (6,100m) in 8.4 min. Service ceiling was 34,500ft (10,515m) and the estimated absolute ceiling was 35,400ft (10,800m).
Convinced that the RAF would buy the new fighter in the prevailing mood of rearmament, the Hawker company decided, in March 1936, to proceed with the production drawings and to make plans for large scale production. Three months later in July, that action was vindicated when the Air Ministry confirmed that 600 Hurricanes were to be included in its expansion Plan F (which also provided for 300 Spitfires). By the time the Battle of Britain began, every single fighter in the hands of the RAF counted, and the early launch of Hurricane production had helped to ensure that just enough machines were in fact available to Fighter Command.
Even so! meeting the RAF's rapidly expanding needs proved to be no simple matter and the Plan F target of 600 Hurricanes to be delivered by March 1939 was missed by some six months. There had been a succession of relatively minor but time consuming problems with prototype development, especially related to the Merlin, and the early intention to fit the Merlin F (Mk I) in the production Hurricane was changed to make use of the improved Merlin G; (Mk II)- which required a redesign of the installation and the front fuselage profile before production could begin. The cockpit canopy also produced its share of problems, with five failures recorded on the prototype before a satisfactory design was evolved.
The first production Hurricane I flew at Brooklands on October 12th 1937, fitted with an early example of the Rolls Royce Merlin II that was rated at 1.030 hp at 16,250 feet (4,955m). This power unit drove a fixed pitch two bladed propeller and at a weight of 5,459lb (2,476kg) the aircraft attained a maximum speed of 318 mph (512 kph) at 17,400 feet (5,305m).
In January 1939, the Merlin II gave way to the Merlin III and with the fitting of a constant speed three bladed propeller and it was this amended specifications that was adopted and all Hurricane Mark I's were constructed using this configuration. Other alterations/additions being the armament which was four Browning .303 machine guns mounted in the wings, metal stressed- skin covered the wings instead of fabric which also covered the fuselage.
By the 27th September 1939, Hawker had delivered 497 Hurricanes to the RAF against the initial order of 3,500 and was enough to equip 18 Fighter Command squadrons. But despite the need to bring Britain's fighter strength to its potential, quite a number of Hurricanes were exported to other countries. 15 went to Turkey, another 15 went to Finland, 12 went to Romania while 1 went to Poland.
During late 1939 and early 1940, 1,924 Hurricanes had been constructed by the Hawker works while Gloster Aircraft who also took on construction built 1,850. Hawker also put out tenders for the construction of the Hurricane overseas. One of these successful tenderer's was the Canadian Car and Foundry Works (CCF) and a licence was issued for the construction of both the Hurricane and the Sea Hurricane. A total of 1,451 machines were built and of these, 60 were flying by 10th January 1940. The Canadian company built the Hurricane in a number of different versions. The original accepted design of the Mark I, the Mark X which were powered by the Merlin 28 engine and built by the Packard Car Co, the Mark XI which was built with Canadian equipment and the Mark XII's that now incorporated the Merlin 29 engine and 12 Browning guns. (8 guns in the Mark XIIA).
Because of the weather conditions in Canada and especially Nova Scotia where many of them were based, the normal retractable undercarriage was dispensed with and fixed skis were used in there place. This allowed the aircraft to take off and land on snow and ice.
During 1939 and 1940, 24 Hurricane Mark I's were delivered to Yugoslavia, and Belgium was also granted a licence to build the fighter although 20 had been acquired from Britain only 15 of these had been delivered.
Hurricane Mark II through to Mark V
June 11th 1940 a Hurricane Mark I was fitted with a two stage supercharged Rolls Royce Merlin XX engine that at sea level was rated at 1,300hp rising to 1,460hp at 6,250 feet. After numerous tests the aircraft was given the designation of Mark II, the improved power plant being the only difference from the Mark I. This first model of the MkII was known as the Series I. Further modifications took place as designers tried to make improvements to the Hurricane. The next model was given the title of Mark II Series 2. The fuselage was given added strengthening which was needed to accommodate the redesigned wings that incorporated attachment points for external stores. A bay was also introduced into the fuselage that also increased the length by a additional 7 inches (7.7mm).
In November 1940, the Mark II Series 2 was given additional firepower by the inclusion of 12 .303 machine guns mounted in the wings. This version was known as the Hurricane IIB. The Hurricane IIC followed by having four 20mm Hispano cannons also mounted in the wings.
Many of these versions flew during the Battle of Britain with a number of Mark II's being fitted with drop-tanks, some being fitted with light to medium bombs while other had increased stores such as additional room for bullets for the machine guns.
After the Battle of Britain, the Hurricane was further developed, mostly up to and including 1942 even though it was relieved as a front line attack aircraft in the air to air war, and was used mainly as a ground attack aircraft. The Mark IIC served until June 1942 when the Hurricane IID appeared which was basically a IIC but with two 40mm cannons and two .303 machine guns.
The Hurricane II gave way to the Hurricane III with a Packard Merlin power plant, then came the Hurricane IV, the first prototype flying on 14th March 1943 which had been previously known as the Hurricane IIE, but after the designation change was fitted with reinforced under wing attachments to carry bombs and rockets and was given the new Merlin 24 engines that put out 1,620hp. A further alteration saw the Mk V which was a Mk IV but given even more power by the fitting of the 1,700hp Merlin 32 engines and having four bladed propellers.
In all, 8,406 Hurricane II's were produced, with 3,000 going to the Soviet Union. In all, only 794 Hurricane IV's were made.
Hawker Hurricane IIC & I Specifications (Mk I in brackets)
| Type | Monoplane (Monoplane) |
| Military Use | Fighter (Fighter) |
| Power Plant | Rolls Royce Merlin XX (Merlin II or III) |
| Horsepower | 1,300hp (1,030hp) |
| Maximum Speed | 327mph @18,000ft (325mph) |
| Climbing Rate | 2,750 ft/min (2,420 ft/min) |
| Working Range | 460 miles (600 miles) @175 mph |
| Empty Weight | 5,658 lbs (4,670 lbs) |
| Loaded Weight | 8,044 lbs (6,660 lbs) |
| Service Ceiling | 35,000 ft (34,000 ft) |
| Wingspan | 40 ft 0 in (40 ft 0 in) |
| Overall length | 32 ft 3 in (31 ft 5 in) |
| Overall height | 13 ft 3 in (13 ft 11.5 in) |
| Total Wing Area | 258 sq feet. (258 sq feet) |
In conclusion, the Hurricane was a fighting plane that pilots agreed would be having a great future. At the time when the first prototype took to the skies, it had performance not yet seen in combat aircraft. Many were, even in the mid-thirties, were looking towards the Spitfire which was already in prototype stages and being based on earlier designs that had won the Schnieder Trophy race and it looked as if it was a race to see what aircraft would be first in production.
But the Spitfire was taking longer to produce in the early stages, and it was the Hurricane that entered service first. Whether it was slow to respond to pilots controls or the rate of climb, but all of the Hurricanes were no match for the Messerschmitt Bf109's which outclassed them.
Air Commodore Peter Brothers CBE, DSO, DFC.formally Fl/Lt P. M.Brothers 32 and 257 Squadrons, has written as follows:-
"As a Hurricane pilot I had a certain fear and respect for the Me 109. For one thing, it could dive faster. If an Me 109 pilot saw you, he would drop down taking a shot at you, go past, pull the stick back and start climbing very fast. You just couldn't keep up with him. The only way to overcome this was to roll over inverted and dive after him in positive g. When the 109 pulled up to level out or climb, I'd aileron-turn to right way up and see his plan view and get in a perfect shot. The visibility in the Hurricane was pretty good, except above and below to the rear. The mirror was useful, but not as effective as it might have been. I replaced mine with a curved rear view mirror, and actually felt it gave me a touch extra speed besides giving a better view.
I once looked in my mirror and saw the biggest, fattest Me 109 ever, or so it seemed. (had the curved 'rear view mirror' contributed to this illusion? - webmaster) All at once his front lit up as he fired at me. The 109 went over the top, to be followed by my Nš2, who was firing at me! When we got down I put him on gun practice for two days and told him "Don't shoot at your friends.....and if you shoot at anything, make sure you hit it!"
In the hands of a skilled pilot, the Hurricane could achieve great success. In fact during the Battle of Britain between July and October 1940, 1,720 of them took part and had the honour of claiming 80% of enemy aircraft shot down by Fighter Command.
The Hurricane's performance was increasing all the time. It was believed that if the Battle of Britain had continued longer, the performance difference between the Mk IIA and the Me 109 was constantly being reduced. Had the Mk II's been powered by the Merlin 32's during the Battle of Britain, then many feel sure that it would have been a certain match for the Me 109.
Return to listing of incidents 'click' on this button.
 |
